The largest and best supported Jaguar cars enthusiast site on the Internet!


Serving Enthusiasts since 1993
The Jag-lovers Web

Currently with 3,166 members





Jag-lovers' Ebooks
- Jag-Lovers' xj40 Ebook -

6.4.3 - Module Repairs ( Brett Gadzinsky,  December 15, 2001 )

The modules are at each corner of the car, close to the lights. Trace the wires from the lights to the module. The modules have a metal cover over a plastic base plate. You need to straighten the bent tabs on the cover, then pull the cover off.

Inside you will find a main board, and maybe a smaller sub board that mounts on its connectors. The main board is held onto the base by four Phillips head screws at each corner. Remove the screws and then the main board.
Solder problem spots are the connectors between the sub board and the main board...re solder both the main board pins and the sub board pins. A very close inspection of the solder joints may show rings around the joint where the solder cracked. Also resolder the relay joints on the main board.

Most of the joints on the little parts will be ok. Also check the relays inside...they operate the lights. If the module looks dirty inside, the relay contacts may also be dirty, and that will cause problems also.

The newer the car, the less problems you are likely to have inside the bulb fail modules.


 

sepbar.jpg (3094 bytes)

This section currently maintained by Pascal Gademer; questions, comments, submissions and suggestions, email pascal@jag-lovers.org

 

Please help support the move to the new site, and DONATE what you can.
A big Thank You to those who have donated already!

 


       
       
       
       

Go to our Homepage
Improve your Jag-lovers experience with the Mozilla FireFox Browser!

  View the latest posts from our Forums via an RSS Feed!

Jag-loversTM Ltd / JagWEBTM 1993 - 2018
All rights reserved. Jag-lovers is supported by JagWEBTM
For Terms of Use and General Rules see our Disclaimer
Use of the Jag-lovers logo or trademark name on sites other than Jag-lovers itself in a manner implying endorsement of commercial activities whatsoever is prohibited. Sections of this Web Site may publish members and visitors comments, opinion and photographs/images - Jag-lovers Ltd does not assume or have any responsibility or any liability for members comments or opinions, nor does it claim ownership or copyright of any material that belongs to the original poster including images. The word 'Jaguar' and the leaping cat device, whether used separately or in combination, are registered trademarks and are the property of Jaguar Cars, England. Some images may also be Jaguar Cars. Mirroring or downloading of this site or the publication of material or any extracts therefrom in original or altered form from these pages onto other sites (including reproduction by any other Jaguar enthusiast sites) without express permission violates Jag-lovers Ltd copyright and is prohibited
Go to our Homepage
Your Browser is: CCBot/2.0 (https://commoncrawl.org/faq/), IP Address logged as 54.80.83.123 on 20th Sep 2018 10:37:42