The largest and best supported Jaguar cars enthusiast site on the Internet!


Serving Enthusiasts since 1993
The Jag-lovers Web

Currently with 3,166 members





Jag-lovers' Ebooks
- Jag-Lovers' xj40 Ebook -

5.3.1 - How To Replace Door Locks ( )

Remove the interior door trim - Remove inner handle surround, slide out wood, remove screws including the one hiding under the rubber air trunking. Remove small middle section (inside pull-handle) to reveal crosshead screw - remove. Also remove screw in red kerb light.

The window lift motor needs removing, but first use plenty of tape to hold the window to the top of the door frame to prevent the glass falling down.

Undo the four nuts that hold the lift motor (no need to unbolt the bottom channel runner).

Undo the connectors, and ease down and out the motor.

Remove the four Torx-headed bolts holding the window frame, and remove a fifth inside the door at the bottom of the front frame. (Don't worry - the frame will not drop down)

Force the frame up so that the window is clear of the weather seal (a bit of a struggle). Untape the glass, and remove. Remove frame. Remove the lock - first undo the cable/ rod connections. Unplug the locks electric's (cut cable ties). Remove Torx bolts holding lock to door frame. Remove lock through bottom of the door.

To refit - reverse procedure.


 

sepbar.jpg (3094 bytes)

This section currently maintained by Pascal Gademer; questions, comments, submissions and suggestions, email pascal@jag-lovers.org

 

Please help support the move to the new site, and DONATE what you can.
A big Thank You to those who have donated already!

 


       
       
       
       

Go to our Homepage
Improve your Jag-lovers experience with the Mozilla FireFox Browser!

  View the latest posts from our Forums via an RSS Feed!

Jag-loversTM Ltd / JagWEBTM 1993 - 2017
All rights reserved. Jag-lovers is supported by JagWEBTM
For Terms of Use and General Rules see our Disclaimer
Use of the Jag-lovers logo or trademark name on sites other than Jag-lovers itself in a manner implying endorsement of commercial activities whatsoever is prohibited. Sections of this Web Site may publish members and visitors comments, opinion and photographs/images - Jag-lovers Ltd does not assume or have any responsibility or any liability for members comments or opinions, nor does it claim ownership or copyright of any material that belongs to the original poster including images. The word 'Jaguar' and the leaping cat device, whether used separately or in combination, are registered trademarks and are the property of Jaguar Cars, England. Some images may also be Jaguar Cars. Mirroring or downloading of this site or the publication of material or any extracts therefrom in original or altered form from these pages onto other sites (including reproduction by any other Jaguar enthusiast sites) without express permission violates Jag-lovers Ltd copyright and is prohibited
Go to our Homepage
Your Browser is: CCBot/2.0 (http://commoncrawl.org/faq/), IP Address logged as 54.80.157.133 on 21st Nov 2017 15:32:15