Part |
Years/Series |
Interchangable Part |
A/C Fan Motor |
All |
Granger Motor Part number 2M197. Uses the same motor as the Heater. See Heater motor. Or Everco P/N M868. |
A/C Expansion valves & orifice tubes |
Series III |
Everco P/N A8250 |
Alternator |
Series III |
Leece-Neville equivalent (Made in USA). Amps are slightly higher but better quality. Used on commercial vehicles
OR Quality Rebuilders P/N 14038 - 60amp. |
Alternator |
70+ 6 cyl |
Quality Rebuilders P/N 14010 - 60 amp. |
Alternator |
64-69 |
Quality Rebuilders P/N 14010 - 45 amp |
Alternator |
64-69 w/ A/C |
Quality Rebuilders P/N 14005 - 45 amp |
Ball Joints (Lower) |
All |
Use the ones from a 1988 XJ40 Part Number CAC9937. Non-Shimed and Sealed. More durable and better. Needs different bolts. (Maybe 5/16"x3/4" fine 24TPI grade 5 bolts w/ split washers. |
Battery (Main) |
All |
Exide Model 34 sku# 1189208. 675 CCA. 75 month warranty. $65 from Montgomery Wards. Slightly smaller than original. Affix Lucus stickers on it and no one will be the wiser. |
Belt - Air conditioning |
69 |
Gates Number 9520 Green Stripe Belt |
Belt - Air conditioning |
70 |
Gates Number 9350 Green Stripe Belt |
Belt - Alternator w/ A/C |
69 |
Gates Number 7250 |
Belt - Alternator w/out A/C |
69 |
Gates Number 7330 33 1/8" Belt O.C. |
Belt - Alternator w/out A/C |
70 |
Gates Number 7340 34 1/8" Belt O.C. |
Belt - Water Pump |
69 |
Gates Number 9313 Green Stripe Belt |
Belt - Water Pump |
70 |
Gates Number 9309 Green Stripe Belt |
Bolts - Intake Manifold and Carb Nuts |
I & II |
Use a standard Fine thread 5/16 zinc plated nut available from most Hardware stores and a 5/16" lock washer. |
Bonnet Safety Latch |
Series I |
Part Number N226-522 (SPB34). A 3-1/4" Zinc plated Double Safety Hasp by National Mfg. Co. Carried by Moss Motors. |
Brake Light Switch |
All |
Upgrade of NAPA/Echlin Part # SL147. Specified as a Stop Light switch. Costs approx. $13. Must recrimp wires with spades from bullets. |
Brakes - Rear |
Series II |
Should be the same as a 1980 XJS |
Clock in Dashboard |
All |
WestClock battery powered clock. Some adapting required. Article link.
Another option - ISI quartz clock. 1 800 558 2674 |
Clutch-Bearing Assembly |
61-64 3.8eng. |
P/N N3035 by CR Seals & Bearings |
Distributor (remanf) |
61-63 |
P/N 31-428 by Cardone |
Distributor (remaf) |
64-71 |
P/N 31-407 w/out vacuum by Cardone
P/N 31-406 w/ vacuum by Cardone |
Distributor-Cap |
64-71 |
P/N LU-423 by Standard Car Parts |
Distributor-Cap |
71-74 |
P/N LU-434 by Standard Car Parts |
Distributor-Coil |
64-71 |
P/N UF-3 by Standard Car Parts w/out ext. resistor
P/N UF-2 by Standard Car Parts w/ ext. resistor |
Distributor-Coil |
74 |
P/N UF-2 by Standard Car Parts |
Distributor-Condenser |
61-71 |
P/N LU-206 by Standard Car Parts |
Distributor-Pickup |
71-74 |
P/N LX-563 by Standard Car Parts |
Distributor-Points |
64-71 |
P/N LU1617XP by Standard Car Parts |
Distributor-Reluctor |
71-74 |
P/N LX-561 by Standard Car Parts |
Distributor-Rotor |
61-71 (manual) |
P/N LU-302 by Standard Car Parts |
Distributor-Rotor |
71-74 |
P/N LU-323 by Standard car Parts |
Engine Bearings/Main Set |
Series I&II |
Federal-Mogul P/N 6129M Std-10-20 |
Engine Bearings/Thrust Washer Set |
Series I&II |
Federal-Mogul P/N 65527BF. Position 4. |
Engine Bearings/Rod Set |
Series I&II |
Federal-Mogul P/N 6-2295RA Std-10-20-30 |
Engine Gasket - Head set |
Series II |
Fel-Pro P/N HS 21140 S-1 |
Engine Gasket - Water Outlet |
Series II |
Fel-Pro P/N 25603 |
Engine Gasket - Exhaust Pipe Flange (2 req.) |
Seris II |
Fel-Pro P/N 23590 |
Engine-Timing Chain |
64-72 4.2L |
Federal-Mogul P/N 222-175 |
Engine-Timing Cover Seal |
63-71 |
P/N 19807 by CR Seals & Bearings |
Engine-Piston Rings |
69+ 4.2L |
Federal-Mogul P/N E-703KC Std only. 2-2.0mm, 1-4.75mm |
Fuel Cap |
61-70 |
Gates Number 31623 non locking
Gates Number 31691 locking |
Fuel Cap |
71-74 |
Gates Number 31738 non locking
Gates Number 31761 locking |
Fuel Filter |
|
The Gas Filter and Glass bowl are available from Napa and Moss Motors.
1) Gas Filter Part Number GF-124....sells at Terry's Jaguar Parts at $4.75 1-800-851-9438
2) Gas Filter Part Number 95039 from Big A auto parts. |
Fuel Filter in gas Tank |
I&II |
FRAM P/N CH8PL |
Fuel Pick-up screen in gast tank |
|
Graco Airless Sprayer P/U screen should be a useable replacement and should be replaced periodically. See Article. |
Fuel Pump |
Series I |
Borg-Warner EP-10 at approx $39. Easy install. Very reliable. 4-6.5psi. |
Heater Fan
|
|
Granger 800-323-0620. Motor Part number 2M197. Approx. $24. Identical but for cutting a flat spot on the shaft and larger mounting bolts. Paint it black, and polarity is important. Puts out more far more air that original.
Or Everco P/N M868. |
Headlights |
|
Hella H4 Haologens |
Hose - Fuel line from filter to carbs |
I&II |
Standard 5/16" Fuel hose from all Auto Parts Stores. About 3 feet of it. |
Hose - Main Upper from Header/Overflow Tank to Intake Manifold |
Series I |
You can use Goodyear Part No gafs074 and cut to size. Has the right bend. |
Hose - Coolant Upper
Motor to Pipe |
74 |
Gates Part 26403 or 25250 |
Hose - Coolant Upper
Pipe to Radiator |
74 |
Two hoses 1 1/4" I.D. type Hot water Hoses |
Ignition Wires |
70 |
P/N 3601 for silicone core Universal wire by Standard Motor Products. |
Knock-Off Hammer |
SI & II |
Recommend Lead Knockoff Hammer. Moss Motors P/N 386-020 88G329. Much nicer to knockoffs than copper. |
Oil Filter Spin-On Conversion |
All |
1) Basset's Jaguar of Wyoming 3/8 extension
2) XK's Unlimited.
3) Flexolite of England. 23 Highway, Yate, Bristol, England BS175AB. Tel/Fax +44(ENG) 454-311401 TSCHUSS.
4) Terry's Jaguar 800-851-9438. Uses FRAM -PH8A or -PH16. |
Oil Filter Original |
61-62 |
Fram Oil Filter CH801BPL with service gasket SP135367 |
Oil Filter Original |
65-68 |
Fram Oil Filter CH801BPL with service gasket SP135367 |
Oil Pressure Switch |
74 |
P/N PS-15X by Standard Motor Products |
Pinion - Bearing (Front) |
61-74 |
P/N M88043/M88010 by CR Seals & Bearings |
Pinion - Bearing (Rear) |
61-74 |
P/N HM90446/HM89410 by CR Seals & Bearings |
Pinion - Seal |
61-74 |
P/N 18679 by CR Seals & Bearings |
Radiator Cap |
61-71 |
4 lb system - Gates Number 31505 w/ safety release
7 lb system - Gates Number 31508 w/ safety release |
Radiator Cap |
72-75 |
14 lb system - Gates Number 31527 spinlok |
Radiator/Cooling Fan |
|
Volvo Turbine Fan from 96 Volvo replacement for Hayden fan. |
Regulator |
Series III |
Leece-Neville equivalent (Made in USA). Amps are slightly higher but better quality. Used on commercial vehicles |
Starter-Brush Set |
70-71 |
P/N LU-278 by Standard Motor Products |
Starter - Refurb. |
72-75 |
Quality Rebuilders P/N 16175 |
Starter - Refurb |
65-71 |
Quality Rebuilders P/N 16138 |
Starter - Refurb |
61-64 |
Quality Rebuilders P/N 16139 |
Steering Racks (Power) |
71-74 |
P/N 26-1911 by Cardone |
Stop Light Switch |
Series I & II |
P/N SLS-34 by Standard Motor Products |
Thermostat |
61-69 |
160 degree - Gates 33006 and Gates Gasket 33635
180 degree - Gates 33008 and Gates Gasket 33635
192-195 degree - Gates 33009 and same Gasket |
Thermostat |
69-74 |
160 degree - Gates 33006 and Gates Gasket 33635
180 degree - Gates 33008 and Gates Gasket 33635
192-195 degree - Gates 33009 and same Gasket |
Thermostat |
75 (V12s) |
180 degree - Gates 33188 and Gates Gasket 33635
192-195 degree - Gates 33189 and same Gasket |
Transmission Filter |
61-71 |
Fram Filter FT1040 for 6 cylinders |
Transmission- Automatic Rear Seal |
60-74 |
P/N 15620 by CR Seals & Bearings |
Transmission-Manual Rear Seal |
60-74 |
P/N 17484 by CR Seals & Bearings |
U-Joints - Rear Half Shafts |
Series I |
P/N UJ 330 by CR Industries" UJ 330. Approx $15.97 each. |
Wheel-Front Inner Bearing |
65-75 |
P/N BR6 by CR Seals & Bearings |
Wheel-Front Outer Bearing |
65-75 |
P/N BR2 by CR Seals & Bearings |
Wheel-Rear Inner Bearing |
61-75 |
P/N BR18590/BR18520 by CR Seals & Bearings |
Wheel-Rear Outer Bearing |
61-75 |
P/N BR18690/BR18620 by CR Seals & Bearings |